2006 Volkswagen Jetta Engine Problems
- 36
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
What owners report
- check engine · 6 records
- engine light · 6 records
- camshaft lifters · 5 records
- camshaft failure · 4 records
Mileage in stored records
| Band | Records |
|---|---|
| 150–400k mi | 11 |
| 60–100k mi | 11 |
| 100–150k mi | 9 |
| 30–60k mi | 3 |
| 1–30k mi | 1 |
Complaint records
Owner-submitted complaint content, presented as stored.
Engine
Tl* the contact owns a 2006 volkswagen jetta. The contact stated that a loud noise emitted from the drive train whenever the vehicle was operated. The noise sounded like something was banging under the hood. The vehicle was taken to an authorized dealer but they were unable to diagnose the failure. The contact examined the vehicle and stated that the fly wheel within the engine needed to be replaced. The vehicle was…
ODI 10463566
Engine · Power Train
On highway going approx 60 mph, car locked up, skidding for about 50 feet. Was unable to engage clutch, engine was still running though. Got car towed to dealership, discovered engine mount bolt had sheared off, car has never been in an accident and has had all oil changes/etc ( 2k miles late for 60k service). *tr
ODI 10461167
Engine
Went to start car was misfiring check engine light came on towed to a shop the told me my timing chain jumped and it was 2500 dollars to fix. *tr
ODI 10668779
Engine
Camshaft began knocking around 100,000 miles. Many other '06 jetta tdi have had premature camshaft failures as well. Knocking intensified just before 101,000 miles. Took it to mechanic who was very familiar with the issue, as he has seen more than his share. He said the earliest failure he has seen was at around 40,000 miles. I had to go to great expense to replace cam follower, camshaft and cam bearings. It also…
ODI 10462870
Engine
Engine stalled while driving at low speed approaching a stop light and could not restart the engine. The engine cranked but would not start. This has happened several times and re-occurred even after the dealer replaced the fuel pump and filter. After only 40 miles and one day of driving it is at the dealer for repair. *js
ODI 10456874
Air Bags · Electrical System · Engine
About 4 years ago ,i took my jetta to the volkswagen dealer in regard to front airbags recall. The light would not go off. They repaired it, but after a year the light came back on and stayed on. When i call the dealer, i was told i would have to pay for an inspection of the car before they can determine if it is defective or not. It seems to me they did not fix the problem and i should not have to pay for it. Also…
ODI 10789697
Electrical System · Electronic Stability Control · Engine
Originally, the turbo would lose boost and the engine would lose power. After some time, particularly during wet weather, the car will suddenly vibrate, jolt, and then the engine warning chime sounds. The tachometer drops to zero, the oil pressure light comes on, the stability control shuts off, the glow plug lights flash, rear window defroster will not work, cruise control wont work, and if the car is shut off it…
ODI 10865770
Engine
Cam wear found on 6/8/11, 195761 miles. Cam shaft wear seen during timing belt change. Replaced cam shaft, followers, and bearings. Factory recommended oil and oil change intervals were used. Cam shaft was also replaced on 11/03/09 at 123086 miles after the following incident: knocking heard from engine while driving on highway near destination, approximately 300 miles from home. Vehicle arrived at destination, but…
ODI 10573002
Engine
Knocking heard from engine while driving on highway near destination, approximately 300 miles from home. Vehicle arrived at destination, but would not start. Vehicle was towed to mechanic. Camshaft wear and follower bore found to be damaged and was replaced using oem parts. Vehicle was using factory recommended oil at regular intervals. Cam wear found again on 6/8/11, 195761 miles. Cam shaft wear seen during timing…
ODI 10573000
Engine
I purchased this 2006 vw jetta tdi 1.9 turbo diesel new in 2006. After only 50k miles, vw dealership stated the turbo charger went bad and the warranty was initially refused stating it was improper oil used. This was disproved with receipts and still charged $500 of a $2300 bill. A few years later now in 2014,the vehicle was taken in for normal service and the next week, engine light came on. The same thing happened…
ODI 10704751
Engine
Tl* the contact owns a 2006 volkswagen jetta tdi. The contact stated that there was a rattling noise in the engine. The vehicle was taken to the dealer where they advised him that the piping had become loose. The vehicle was repaired by applying a rubber guard however, the failure recurred immediately after the repairs. The vehicle was taken back to the dealer where they advised him that the duel mass flywheel…
ODI 10500941